Front Rank Steel Furnace Co. v. Wrought Iron Range Co.

PRIEST, District Judge. This case comes before me on an ordel sustaining a petition for review, and is placed in very narrow lines by the order. The cause was heard by Judge Hallett, who ordered an interlocutory decree, adjudging the complainant’s patent valid, and awarding an injunction and accounting against the defendant for infringement of letters patent No. 414,018, to Francis M. Campbell, inventor, and William Thuener, assignee, for an improvement in hot-air furnaces. No written opinion was filed by Judge Hallett. While submitting his oral views, which were very imperfectly reported, he observes: “I shall not discuss this matter at great length, but I must say, again, I think the complainant’s device, comprehending, as it does, the location of the several flues, the upward and the side, and the manner of connecting with the fire chamber, and the introduction of the cold air, may be of the nature of invention.” Judge Hallett bad .before him several furnaces of similar construction, and involving much the same principle of action, as that of complainant’s. A petition was filed upon the ground of newly-discovered evidence, and the attention of the court was called particularly to the Powell and Krause furnaces, the former of which was put in use as early as 1884, and the latter in 1888. Upon this showing, Judge Hallett ordered—- “That a rehearing be allowed at the next term of the court upon the question of the novelty of complainant’s invention with reference to the Powell furnace and the Krause furnace, mentioned in respondent’s affidavits filed June 24, 1893.” The necessary steps marked out in the order have been taken to present the question thus reserved. Whatever might be my disposi — 996 — tion-otherwise, I felt constrained to the consideration of this single quéstión and such others only-as are strictly incidental to and necessarily grow out .of it,, though counsel have given attention in their respective arguments to quite all the issues involved in the contest as it originally stood. The respondent mainly relies, so far as this Hearing is concerned, upon the Powell furnace as an anticipation of:'.the -complainant’s furnace. The number of anticipations is not material. If one perfected and used has preceded, it is sufficient to defeat the validity of the patent relied upon. This, then, at once introduces the question whether the Powell furnace was an anticipation of the . complainant’s. The Campbell patent, under which cornplainant- claims, is,for an improvement in hot-air furnaces,, “which relates especially to the system of flues traversed by the products of combustion in their escape from the combustion chamber.” The arrangement’of complainant’s furnace is thus described: “Leading from the upper portion of the combustion chamber, which is practically an upright, chamber, in the customary form, are two- horizontal escape,, flues, B, B', which lead, respectively, into two vertical flues, O, O',, at and towards the upper portion thereof. The upright flues at the lower and thereof connect with a horizontal chamber, D, towards the ends of it. The exit from the horiz.o-ntal chamber is by moans of an upright flue, E, which rises from the center of the chamber midway between the vertical flues, 0, O', and at fits' upper -end connects with any suitable escape flue. Cold air is admitted into the hot-air chamber at the rear of the furnace, and directly to the rear, and under the-chamber to. which the two upright flues unite.” ’ , The operation of the furnace is described in the specifications as follows: ■ “The heated products .of combustion escape from the chamber A into descending flues, 0, O', whjch are’ quite large in diameter and larger than the flue E. Owing to, their size and the,, use of the pair of them, the flues O, C'„ are sufficient for the chamber A, and no direct escape is needed. The-course from the flues 0, O', is downward into the chamber D, which serves not only to provide. an .additional heating service, but also as a dus.t chamber, and as a guard to favor the delivery of the incoming cold air towards the central, portion, of the hotair chamber. From the chamber D the escape is as stated upward through the flue E.” . Three claims are predicated on these specifications, the first and third’ of 'which are' necessary to notice: ' “(1) In. a furnace the combination with the hot-air chamber, having an air-inlet'in one side-near its-bottom, of the combustion chamber, situated eccentrically .within the hot-air-’chamber, and adjacent to the side thereof, opposite that having.the air inlet, the flues B, B', extending from the inner-side i of, the combustión .chamber .near the top thereof, the descending flues C, O', 'communicating at' the top with the' flues B, B', respectively, the chamber T)' communicating- with the lower ends of the flues G, O', and ’the ascendingffiue E-rising centrally from the chamber between- the flues B;-B’, substantially as specified.” ' ■ “(3) In the furnace the combination with the hot-air chamber and the combustion' chanibér,, situated eccentrically therein, of the .flues ’ B, B', extending from' the top of the combustion chamber, the ’ descending flues O,"'0', óf lárgñ diameter, Communicating' respectively with the flues B, B', the heating chamber D communicating with the lower ends "of the flues O, O',-and, the ascending .flue E rising from-the chamber. D between- ,tbe flues O, 0','. of much smaller diameter than the latter flues, as .and for the purpose-set forth.” ........... — 997 — The virtues of this special mode of construction or system of escape flues are particularly dwelt upon in the specifications. Of the vertical flues C, C', it is said, owing to their size and the use of a pair of them, they are sufficient for the combustion chamber, and no direct escape is needed. Of the horizontal chamber it is claimed that it not only provides additional heating service, but also a dust chamber and a guard to favor the delivery of the incoming cold air through the central portion of the hot-air chamber. In addition to this the dust chamber is not connected with the combustion chamber, and Ihe space between Hie two affords an opportunity for the air to rise. The ascending flue E is smaller than the descending flues O, O', which is for the purpose of retarding the descent through the flues C, O', and increasing the heating service thereof, and, by means of the retardation of the product of combustion, the greatest possible amount of heat will be thrown out from the descending flues into the hot-air chamber; and, because of this difference in size between the flue E and the flues C, O', the air will pass much more rapidly upward through the flue than it can descend through the flues 0, O'. I assume that this arrangement of flues has in it the quality of an invention. The Powell furnace is constructed upon the same operative principle as that of the complainant’s, the mechanical structure differing only in a few slight, and, to inv apprehension, unimportant, particulars. In other words, if the complainant’s furnace be an improvement on the Powell furnace, it is one of degree, and not of kind; and as was said in the case of Burt v. Evory, 133 U. S. 349, 358, 10 Sup. Ct. 394: ‘•The test is that the improvement must be the product of an original conception (Pearce v. Mulford, 102 U. S. 112, 118; Slawson v. Railroad Co., 107 U. S. 649, 2 Sup. Ct. 663; Munson v. Mayor, etc., 124 U. S. 601, 8 Sup. Ct. 622; and many other cases); and a mere carrying forward or more extended application of an original idea—a mere improvement in degree - is not invention.” The same idea was more fully expressed by Mr. Justice Strong in Smith v. Nichols, 21 Wall. 112, as follows: “But, a mere carrying forward or new or more extended application of the original thought, a change only in form, proportions, or degree, the substitution of equivalents doing subs! antially the same ihing, in the same way, by substantially the same means, with better results, is not such invention as will sustain a patent. These rales apply alike whether what preceded was covered by a patent, or rested only in public knowledge and use. In neither ease can there be an invasion of such domain and an appropriation of anything found therein. In one case, everything belongs to the prior patentee; in the other, to the public at large.” Counsel for complainant insists that complainant’s furnace, as described in the specifications and claims of the Campbell patent, differs from the Powell furnace in the following particulars:' First. That, unlike complainant’s furnace, its parts were not intended to operate with a single cold-air inlet at the rear, but with two cold-air inlets at the sides. Second. The lower horizontal chamber was located on an ash-pit extension, whereas in (.he Campbell patent an air passage exists between the ash pit and the horizontal chamber D. Third. In the Powell furnace the down flues are constructed — 998 — so as to be smaller than the up flues. The method of introducing the cold air at the rear is not an essential claim of the Campbell patent. If so, it appears that the patent would have been refused, because that method of introducing, cold air had long prior been in use. Complainant’s claim must rest upon the arrangement of a system of flues for the product of combustion. To such a design the specifications limit and commit it. The place of introducing the cold air is a nonessential. The attachment of the horizontal chamber to the ash pit in the Powell furnace, whereas in the Campbell furnace it is independent of such connection, does not destroy the identity of principle in operation or design. It may be conceded, because of the nonattachment of this chamber to the combustion chamber or ash pit, the hot air would rise more freely than in the Powell furnace; yet this does not impeach the identity of principle in the operation of the two, but only the degree, and is not the product of inventive skill. It is manifest, not only from the physical structure of the Powell furnace, but the fact is clearly emphasized by the testimony, that there is a free circulation upwardly of air between the combustion chamber and the down flues in the Powell furnace. Moreover, just such an independent arrangement of the horizontal chamber D is found in the Bingen furnace of 1885. In the Powell furnace the two vertical chambers or flues are contracted at the lower end, but the body of these flues are larger in diameter than the escape flue located between them. They operate precisely alike and upon the same principle. An equivalent of this is found in the smaller horizontal flues B, B', of the Campbell furnace. Counsel for complainant seems to realize that the Powell pattern of furnace stands conspicuously in the way of the Campbell patent, and, to overcome this impediment, strives, for the first time on this rehearing, to show that Campbell completed and perfected his invention as early as January, 1884, but was prevented, by lack of pecuniary means, from pressing an application for grant of letters patent. If I am right in concluding that the Campbell furnace is an essential duplicate of the Powell furnace, this argument cannot avail the complainant. The Powell furnace was put in public use in 1884, and to a limited extent has been in service ever since. The Campbell patent was applied for in February, 1889. Section 4886, Bev. St., provides that: “Any person who has invented or discovered any new and useful art, machine, manufacture or composition of matter, or any new and useful improvement thereof not known or used by others in this country or any foreign country * * * not in public use or on sale for more than two years prior to his application, * * * may * * * obtain a patent therefor.” The interpretation of this statute by the supreme court in the case of Andrews v. Hovey, 123 U. S. 267, 8 Sup. Ct. 101, clearly defeats this contention of complainant. In a case to which reference is made in the opinion just referred to, and speaking with reference to the policy of the statute, it is said— “That the inventor must apply for his patent within two years after his invention is in such a condition that he can apply for a patent for it, — 999 — and that i£ he does not apply within such time, hut applies after the espiral ion of such time, and obtains a patent, and it appears that his invention was in public use at a time more, than two years earlier than The date of his application, iiis patent will bo void, even though such public use was without his knowledge, consent, or allowance, and even though he was in fact the original and first inventor of the thing patented and so in public use.” If Campbell’s plans,oí furnace wore complete in conception in January, 188 f, it was his duty to give it to the public for use at the earliest practicable time. Inventive talent is encouraged that public comfort, utility, and convenience may be augmented. It has been well said: “.Justice requires that the public should reward those only who keep faith with it, who apply their creativo energies to the promotion of the irablic good, and who, having generated ideas, reduce them as speedily as possible to practical and beneficial public use.” 1 Rob. Pat. p. 546. We are entitled to presume that the conception is contemporaneous with the application; but, waiving this and the further presumption that a failure to apply for a patent evidences an incomplete and imperfect conception, the circumstances that would justify the inventor in withholding his invention from public use for a period of four or five years must he of a more immoderate character tlum I find to exist in this case. But conception alone, although complete, is not sufficient; for, when the patentee proposes to assert that his invention was anterior to the date of his application, he must not only prove that he made the invention at the period suggested, but that, he reduced it to practice in the form of an operative machine. Johnson v. Root, 2 Cliff. 116, Fed. Cas. No. 7,409. No effort has been made to prove the construction of a furnace prior to 1888. Complainant's counsel cites us to those cases which seem to encourage experimental tests in order to perfect the instrument before applying for patent, as if. by such reference, to lead us to suppose that Campbell was demonstrating the value or perfecting the detail of his invention throng’ll such actual experiments. Of this I find no evidence in the record. If, however, he were thus engaged, he assumed the chances of the field being occupied by other and more diligent designers, more prompt to supplement their creative efforts by a reduction to practice. The fact is, the Powell furnace was constructed and satisfactorily employed in 1884, incorporating all of the mechanical elements of construction and arrangement, and combining all of the operative principles, obtaining in the Campbell furnace. The bill will be dismissed, at complainant’s costs.